Quarantine Pedalboard Project



Moderator: Ghost Hip

Re: Quarantine Pedalboard Project

Postby Benn Roe » Sun Nov 29, 2020 2:02 am

I didn't take any pictures of actually gluing the at-this-point cut tolex to the rest of the frame, because I needed to glue it all down pretty quickly after spraying, but I think these pictures give a pretty good idea of how I cut everything to make it fit. What I ended up with was a fully covered frame with seams at the corners on the sides and top, as well as along the inside bottom edge. Some of it turned out a little sloppy. Most of it is fine. Where the wood peeks through a bit, I just painted it to the approximate colour of the tolex, and you can't really tell without very close inspection. I assume this will need to be redone properly at some point, but it should look fine for a good long while.

41 Tolexing (small).jpg

42 Tolexing (small).jpg

43 Tolexing (small).jpg
Last edited by Benn Roe on Sun Nov 29, 2020 2:33 am, edited 2 times in total.
Former Bands: Lazy Gaga, Kadis-kot, Pyramids, In First Person, the Holy Fucking Spirit, Take Down Your Art, A Petal Fallen
Benn Roe

experienced
experienced
 
Posts: 668
Joined: Fri Jun 17, 2016 5:36 pm
Location: Philadelphia, PA

Re: Quarantine Pedalboard Project

Postby Benn Roe » Sun Nov 29, 2020 2:11 am

After fitting the carpeted top into the tolexed frame, I installed and wired up all the electronics, as well as installing some straps (without which I would literally never be able to get the board out of its case). I used some pre-grometed tree landscaping straps with luggage handles added to them, and just bolted them on somewhat loosely, with liberal washer usage, so that they can be stored on top of the board when it's in its case (for ease of removal), but tucked under the board during usage. I apparently again neglected to document the pre-drilling of the holes for these straps, but I obviously did all that before adding the tolex. At this point the board was done, so the rest of these pictures are basically just porn.

44 Assembled (small).jpg

45 Assembled (small).jpg

46 Assembled (small).jpg
Last edited by Benn Roe on Sun Nov 29, 2020 2:18 am, edited 1 time in total.
Former Bands: Lazy Gaga, Kadis-kot, Pyramids, In First Person, the Holy Fucking Spirit, Take Down Your Art, A Petal Fallen
Benn Roe

experienced
experienced
 
Posts: 668
Joined: Fri Jun 17, 2016 5:36 pm
Location: Philadelphia, PA

Re: Quarantine Pedalboard Project

Postby Benn Roe » Sun Nov 29, 2020 2:14 am

47 Wired (small).jpg

48 Wired (small).jpg

49 Wired (small).jpg
Former Bands: Lazy Gaga, Kadis-kot, Pyramids, In First Person, the Holy Fucking Spirit, Take Down Your Art, A Petal Fallen
Benn Roe

experienced
experienced
 
Posts: 668
Joined: Fri Jun 17, 2016 5:36 pm
Location: Philadelphia, PA

Re: Quarantine Pedalboard Project

Postby Benn Roe » Sun Nov 29, 2020 2:17 am

50 Straps (small).jpg

51 Fully Wired (small).jpg

52 Complete (small).jpg
Former Bands: Lazy Gaga, Kadis-kot, Pyramids, In First Person, the Holy Fucking Spirit, Take Down Your Art, A Petal Fallen
Benn Roe

experienced
experienced
 
Posts: 668
Joined: Fri Jun 17, 2016 5:36 pm
Location: Philadelphia, PA

Re: Quarantine Pedalboard Project

Postby Benn Roe » Sun Nov 29, 2020 2:21 am

53 Complete (small).jpg

54 Complete (small).jpg

55 Complete (small).jpg
Former Bands: Lazy Gaga, Kadis-kot, Pyramids, In First Person, the Holy Fucking Spirit, Take Down Your Art, A Petal Fallen
Benn Roe

experienced
experienced
 
Posts: 668
Joined: Fri Jun 17, 2016 5:36 pm
Location: Philadelphia, PA

Re: Quarantine Pedalboard Project

Postby Benn Roe » Sun Nov 29, 2020 2:22 am

56 Complete (small).jpg

The end.
Former Bands: Lazy Gaga, Kadis-kot, Pyramids, In First Person, the Holy Fucking Spirit, Take Down Your Art, A Petal Fallen
Benn Roe

experienced
experienced
 
Posts: 668
Joined: Fri Jun 17, 2016 5:36 pm
Location: Philadelphia, PA

Re: Quarantine Pedalboard Project

Postby Dandolin » Sun Nov 29, 2020 9:03 am

whoa - awesome! very impressive, and great to be able to see your process and all the planning and execution that went into this. :)* :thumb:
"In a moment of unparalleled genius, Noel Parachute headed off this potential disaster by unplugging the microphone."
Dandolin

User avatar
IAMILFFAMOUS
IAMILFFAMOUS
 
Posts: 11108
Joined: Thu Oct 15, 2009 2:33 pm
Location: On the pharm in PA

Re: Quarantine Pedalboard Project

Postby Achtane » Sun Nov 29, 2020 5:44 pm

Nice job! It looks good. Is it very heavy? Tolex has always sounded like a real pain in the ass to work with, but maybe it's not so bad after all. That's pretty cool.
http://www.youtube.com/watch?v=Louy7zH9guw
sonidero wrote:Roll a plus 13 for fire and with my immunity to wack I dodge the cough and pass a turn to chill and look at these rocks...

kbithecrowing wrote:Making out with my girl friday night, I couldn't stop thinking about flangers.

Image
Image
Achtane

User avatar
IAMILFFAMOUS
IAMILFFAMOUS
 
Posts: 14313
Joined: Mon Sep 20, 2010 2:09 am
Location: under the manchineel

Re: Quarantine Pedalboard Project

Postby Benn Roe » Sun Nov 29, 2020 7:38 pm

Thanks, dudes! It is heavy, but it ranges from heavy-but-manageable with the straps to ungodly-unless-you-wheel-it-around-like-luggage while it's in the case. Thankfully the case does have luggage wheels on both sides, so it's fine. I don't think it's any heavier than any other board this size is likely to be, though, honestly. I guess if it were a flat board in a soft case it would be a little lighter, but it would still be crazy unwieldy. The pine frame is super light. The MDF top is obviously dense and a little heavy, but most of the weight is just the power supplies and pedals. The panels on the case are plastic, not wood, so that helps a bit too. The real problem is that it doesn't fit in my car without putting the seats down, and there are normally three of us riding to band practice in the same car, so I wouldn't be able to bring it back and forth between home and the practice space unless our other guitarist found her own way to practice. It's technically my wife's car, and she's our drummer, so she gets to stay.

For those who might be interested, here's the signal path sketch you can see smaller in one of the above pictures. It's a bit much, but, you know, it's a lot of pedals and it was a lot of MIDI capability and expression control to otherwise be leaving on the table.

Signal.jpg
Former Bands: Lazy Gaga, Kadis-kot, Pyramids, In First Person, the Holy Fucking Spirit, Take Down Your Art, A Petal Fallen
Benn Roe

experienced
experienced
 
Posts: 668
Joined: Fri Jun 17, 2016 5:36 pm
Location: Philadelphia, PA

Re: Quarantine Pedalboard Project

Postby coldbrightsunlight » Wed Dec 02, 2020 6:03 am

Wow that's a serious setup and build! Looks clean, but also nightmarishly heavy :lol:
füzz lover. Friend. Quilter evangelist.

I make music sometimes:

https://nitrx.bandcamp.com/

https://mediocrisy.bandcamp.com/

https://fleshcouch.bandcamp.com
coldbrightsunlight

User avatar
Supporter
Supporter
 
Posts: 13522
Joined: Tue Oct 12, 2010 12:20 pm
Location: UK

Re: Quarantine Pedalboard Project

Postby Dowi » Wed Dec 02, 2020 6:11 am

Can't imagine the amount of work that went in planning and executing this, but the result is super clean. Amazing work, I wouldn't want to carry it around though, unless i want backache for weeks.
BIRCH BARK | Solo stuff | Bandcamp - Youtube
HIBAGON | Polyrhythmic Heavy Duo | Bandcamp - Spotyshit
Dowi

User avatar
IAMILF
IAMILF
 
Posts: 2649
Joined: Fri Jan 08, 2016 8:12 am
Location: Italy

Re: Quarantine Pedalboard Project

Postby Benn Roe » Thu Dec 03, 2020 9:08 am

Thanks, guys! I'm definitely a glutton for punishment when it comes to heavy gear.
Former Bands: Lazy Gaga, Kadis-kot, Pyramids, In First Person, the Holy Fucking Spirit, Take Down Your Art, A Petal Fallen
Benn Roe

experienced
experienced
 
Posts: 668
Joined: Fri Jun 17, 2016 5:36 pm
Location: Philadelphia, PA

Re: Quarantine Pedalboard Project

Postby goroth » Mon Apr 26, 2021 6:38 am

I missed this the first time round. Cool read! How you liking the behemoth?
ALLisNOISE wrote:you can dial in some wonderfully smeared 12bit cascades of cicadas leveling a hail of rockets against an army of rusty box fans!

Latest album out on all streaming services and bandcamp and what not.
Spotify /// Apple Music
My band /// Instagram ///Bandcamp ///
goroth

User avatar
HERO
HERO
 
Posts: 13477
Joined: Wed Jan 25, 2012 3:50 am
Location: Eurothrash: Frozen northern outpost.

Previous

Return to Guitar Tech & Projects



Who is online

Users browsing this forum: No registered users and 5 guests


Sponsored Ad. (Please no inflated/repetitive clicking. Thanks!)



ilovefuzz.com is not responsible for user-submitted content. Users participate at their own discretion and risk.